Dietary contribution of iron from limestone and dicalcium phosphate for broiler chickens.

Iron is routinely supplemented in broiler feeds aiming to prevent dietary deficiencies. Limestone and phosphates are very rich in Fe; however, its contribution from these sources have not been thoroughly investigated with chickens. The present research was conducted to evaluate live performance and blood parameters of broilers when using limestone and dicalcium phosphate as sources of Fe. A total of 576 one-day-old male Cobb x Cobb 500 were allocated into a total of 72 battery cages, 6 treatments with 12 replication cages of 8 chicks at placement. Chicks were fed diets formulated with corn, soybean meal (SBM) with laboratory grade calcium carbonate and phosphoric acid (having traces of Fe). All chicks were fed a common prestarter without Fe supplementation (analyzed total 58.2 ± 2.4 mg/kg Fe) from placement to 7 d. Allocation of birds to dietary treatments was completely randomized on day 8. Treatments had increasing Fe derived from commercial limestone and dicalcium phosphate (analyzed Fe 7,218 and 4,783 mg/kg, respectively) progressively replacing calcium carbonate and phosphoric acid to provide graded increases in total Fe (analyzed Fe in the feeds were 57.6 ± 2.1, 92.0 ± 2.3, 124.1 ± 2.7, 159.3 ± 3.1, 187.2 ± 3.2, 223.7 ± 3.6 mg/kg, respectively). There were no effects of dietary Fe on live performance, hematocrit, and hemoglobin the end of the study on day 28 (P > 0.05). Increasing dietary Fe from commercial limestone and dicalcium phosphate led to a linear reduction in the percent ileal digestible Fe. However, linear increments in Fe retention, serum ferritin and liver Fe occurred when compared to feeds without Fe derived from limestone and phosphate dicalcium. It is concluded that Fe from limestone and dicalcium phosphate can be partially utilized by broiler chickens. It was estimated that the Fe retained from limestone and dicalcium phosphate is of 1.9%. Broilers fed corn-soy feeds (58.2 mg/kg Fe) do not require supplemental Fe.

Chicken liver morphology as affected by feed withdrawal time and dietary aflatoxins.

1. An investigation was conducted on the effects of aflatoxin (AFL)-contaminated diets and feed withdrawal periods from 0 to 12 h in broiler chickens at 28 d of age. Both factors can potentially affect liver colour and can cause failure at veterinary inspection in the slaughterhouse.2. A total of 240, one-d-old female Cobb 500 broiler chickens were fed a common corn-soy pre-starters (d 1-7) and then either a non-contaminated control (CON) or feed with 1 ppm AFL (AFL) from d 8 to 28. The inoculum of AFL had 792 ppb of aflatoxin B1, 35 ppb of aflatoxin B2 and 219 ppb of aflatoxin G1. On d 28, all broilers were weighed and euthanised for necropsy following three different feed withdrawal time periods (0, 6 or 12 h), in a 2 × 3 factorial arrangement.3. Body weight gain, liver weight and liver fat content decreased as feed withdrawal lengthened, whereas FCR and gallbladder weight increased (P ≤ 0.05). AFL-fed birds had reduced body weight and proportion of liver fat and increased FCR, liver and gallbladder weights (P ≤ 0.05).4. Livers from fed broilers (0 h withdrawal) showed more lightness (L*) and yellowness (b*) than livers of broilers from 6 or 12 h withdrawal (P ≤ 0.05). The L* and redness (a*) values of livers from broilers fed diets COB were lower than those from AFL fed broilers (P ≤ 0.05).5. Prolonging pre-slaughter feed withdrawal decreased liver L*, whereas feeding AFL increased liver b*. These findings can be used to support veterinary assessment in slaughterhouses as shackled birds move on line through the inspection site. Since chicken liver is a valuable organ and an indicator of animal health, attention must be paid to these differences to ensure consumer safety.

Progressive in vivo detection of wooden breast in broilers as affected by dietary energy and protein.

Wooden breast (WB) myopathy was investigated in broilers fed varying energy and protein at early ages. Correlation analyses were conducted between echogenicity of ultrasound images (US) of breast muscle from live birds and WB after slaughter. A total of 1,000 Cobb 500 one-day-old male chicks were fed on five dietary programs with eight replicates of 25 birds each, in a completely randomized design. Control feeds (commercially used ME and ideally balanced amino acids) or low-density feeds (low EP, with reductions of 50 kcal/kg ME and 0.20% dig. Lys compared to the control) were formulated. Feeds were provided in different periods: 1 to 7 d, 8 to 14 d, 15 to 21 d or 22 to 28 d. All broilers were fed a common basal diet thereafter until 49 d. Images using US were obtained once a week from all individuals and WB scored from one slaughtered bird per replication (0, normal; 1, mild hardening in the upper breast muscle; 2; moderate hardening in the upper and/or lower breast muscle; 3, severe hardening; 4, severe hardening with hemorrhagic lesions and yellow fluid). Blood was collected for enzyme investigation from the weekly slaughtered bird. Broilers had lower BWG and higher FCR when fed low EP feeds, regardless of the period fed when compared to the control (P < 0.001). Growth compensation, however, occurred afterwards such that all birds presented similar performance at the end. At 14, 21, and 28 d, broilers previously fed low EP feeds had lower WB scores (P < 0.001) compared to birds fed the control; however, both groups presented increased WB scores after 28 d. Wooden breast was positively correlated with breast echogenicity at 21 d (r = 0.31), 28 d (r = 0.43), 35 d (r = 0.21) and 42 d (r = 0.39). In conclusion, dietary energy and protein affected the development of WB scores in broilers and breast US images can be used as an early predictor of WB.

Manganese requirements of broiler breeder hens.

The present research was conducted to assess Mn requirements of broiler breeder hens. One hundred and twenty Cobb 500 hens, 22 wk of age, were individually allocated in cages. After fed a Mn-deficient diet (22.2 ppm), hens were randomly placed in treatments having 6 increments of 30-ppm Mn. All trace minerals were from laboratory grade sources being Mn from Mn sulfate (MnSO4H2O). Treatments were fed for 4 periods of 28 d. There were no interactions between dietary Mn and period for any evaluated response (P > 0.05). Requirements of Mn for hen day egg production and settable egg production were 115.8 and 56.6 ppm and 122.1 and 63.6 ppm (P < 0.05), respectively, using quadratic polynomial (QP) and broken line quadratic (BLQ) models, whereas total eggs and total settable eggs per hen had Mn requirements estimated at 115.7 and 56.6 and 121.8 and 61.7 ppm (P < 0.05), respectively. Number of cracked, defective, and contaminated eggs decreased, whereas hatchability, hatchability of fertile eggs, eggshell percentage, and eggshell palisade layer increased when hens were fed diets having 48.5 to 168.2-ppm Mn (P < 0.05). Maximum responses for egg weight and eggshell percentage were 117.7 and 63.6 ppm as well as 131.6 and 71.0 ppm (P < 0.05), respectively, using QP and BLQ models. Breaking strength and egg specific gravity had Mn requirements estimated at 140.2 and 112.7 ppm as well as 131.3 68.5 ppm (P < 0.05), whereas eggshell palisade layer and eggshell thickness were maximized with 128.8 and 68.8 ppm and 140.2 134.2 ppm, respectively, for QP and BLQ models (P < 0.05). Maximum yolk Mn content values were obtained using 118.0- and 118.4-ppm Mn by QP and BLQ models, respectively. The average Mn requirements estimated for QP and BLQ models is 128.4 and 92.3 ppm Mn (18.7 and 13.5 mg/hen/d), respectively, which is much lower than what has been currently recommended in commercial production.

An in vivo evaluation of the effects of feed restriction regimens on wooden breast using ultrasound images as a predictive tool.

1. Gradual feed restriction was applied to broilers in order to reduce growth rate and, as a consequence, gradually impacts wooden breast myopathy occurrence. Ultrasound (US) images of breast muscle in live birds were correlated with breast fillets presenting wooden breast characteristics (WB). 2. A total of 1800 Cobb × Cobb 500 slow-feathering male chicks were fed one of the six feed restriction treatments with 12 replicates of 25 birds each, in a completely randomised design. Birds were fed ad libitum or were pair-fed to 50%, 60%, 70%, 80% or 90% of normal ad libitum intakes from 8 to 49 d to provide a gradual reduction in growth rate. Ultrasound images were obtained weekly from all birds and, in parallel, one bird per pen was weekly slaughtered and the major breast muscle was weighed and WB graded as 0 (normal), 1 (mild hardening in the upper), 2 (moderate hardening in the upper and/or lower), 3 (severe hardening) and 4 (severe hardening with haemorrhagic lesions and yellow fluid). Blood was taken for analysis of enzymes related to muscle cell breakdown. 3. Feed restriction applied at 50%, 60%, 70%, 80% and 90% of the ad libitum feed intake (FI) resulted in decreased body weight gain (BWG; P ≤ 0.05). 4. From 21 to 49 d, the increasing feed restriction led to linear increases (P ≤ 0.05) in WB scores, fibre density as well as breast depth and breast echogenicity. Creatine kinase, lactate dehydrogenase and aspartate aminotransferase concentration decreased linearly when broilers were feed restricted (P ≤ 0.05). 5. Wooden breast was positively correlated with echogenicity at 21 d (r = 0.510), 28 (r = 0.531), 35 (r = 0.470), 42 (r = 0.430) and 49 d (r = 0.548) (P ≤ 0.001). The use of breast echogenicity can be an additional tool to early detect alterations related to wooden breast.

Utilization of corn-based diets supplemented with an exogenous α-amylase for broilers.

A study was conducted to evaluate the effects of a supplemental α-amylase on energy and nutrient utilization of broiler chickens fed diets with variable amounts of corn. A total of 480 slow feathering Cobb × Cobb 500 male broilers were randomly distributed into 10 treatments with 8 replicates of 6 birds each. Birds were fed a common starter to 14 D post-hatch. The experimental diets were provided subsequently until 25 D, which were a conventional corn-soy basal diet (CS) and a corn-soy diet displaced with 40% of corn (CN). These were fed as-is or supplemented with 40, 80, 120, or 160 kilo-Novo α-amylase units (KNU)/kg. Dietary treatments were distributed factorially as a 2 × 5 arrangement (diet type vs. amylase). Samples of feed, excreta, and ileal digesta were analyzed for determination of ileal digestible energy (IDE), ME, total tract retention, and digestibility of dry matter, protein, and fat. No interactions between diet type and amylase were observed. The CN diet had lower (P < 0.05) energy utilization and nutrient digestibility when compared to the CS diet. AMEn and IDE increased (P < 0.05) by 110 and 207 kcal/kg, respectively, when CS and CN diets were supplemented with 80 KNU/kg. The amylase added to the CS diet led to quadratic increases (P < 0.05) on growth performance, IDE, AME, and AMEn, as well as in dry matter, protein, and fat digestibility. Energy utilization and crude protein digestibility were linearly increased (P < 0.05) when amylase was added to the CN diet or the extrapolated 100% of corn. In conclusion, energy utilization, digestibility of crude protein, fat, and dry matter increased with amylase supplementation in corn-soy-based diets. When amylase was tested in a complete diet having 53.6% corn, 100 and 105 KNU/kg maximized AMEn and IDE, respectively; however, the maximum energy response in the CN diet or 100% of corn was not achieved until 160 KNU/kg, suggesting an association between amylase dose optimization and dietary starch concentration.

Zinc requirements of broiler breeder hens.

One hundred and twenty Cobb 500 hens, 20 wk of age, were randomly allocated into individual cages with the objective of estimating their Zn requirements. The study was composed of 3 phases: adaptation to cages (basal diet), depletion (deficient diet containing 18.7 ± 0.47 ppm Zn) for 7 wk, and experimental phases. Hens were fed diets with graded increments of Zn sulfate heptahydrate (ZnSO4·7H2O), totaling 18.7 ± 0.47, 50.3 ± 10.6, 77.3.0 ± 11.0, 110.2 ± 12.8, 140 ± 12.2, and 170.6 ± 13.2 ppm analyzed Zn in feeds for 12 wk (experimental phase). Requirements of Zn were done using quadratic polynomial (QP), broken line quadratic (BLQ), and exponential asymptotic (EA) models. In general, the non-linear statistical models were the ones that best fit the results in this study. Requirements obtained for hen day egg production and settable egg production were 83.3, 78.6 ppm and 61.4, 65.4 ppm for period of 33 to 36 wk, and 63.3, 53.1 and 60.4, 46.1 ppm for period of 37 to 40 wk, and 62.8, 52.8, and 67.7, 62.1 ppm for period of 41 to 44 wk, respectively, using BLQ and EA models. Total eggs and total settable eggs produced per hen had Zn requirements estimated as 75.7, 64.7 ppm, and 56.5, 41.5 ppm, respectively, for BLQ and EA models, whereas for alkaline phosphatase and eggshell percentage were 161.8, 124.9 ppm and 126.1, 122.4 ppm, using QP and BLQ models. Maximum responses for Zn in yolk for periods of 37 to 40 and 41 to 44 wk were 71.0, 78.1 and 64.5, 59.6 ppm, respectively, using BLQ and EA models. Breaking strength had Zn requirements estimated at 68.0 and 96.7 ppm, whereas eggshell palisade layer and eggshell thickness were maximized with 67.9, 67.9 ppm, and 67.7, 64.4 ppm, respectively, for BLQ and EA models. The average of all Zn requirement estimates obtained by EA and BLQ models in the present study was 72.28 ppm or 11.1 mg/hen/d.

Copper requirements of broiler breeder hens.

One-hundred-twenty Cobb 500 hens, 20 wk of age, were randomly allocated into individual cages with the objective of estimating Cu requirements. After being fed a Cu deficient diet for 4 wk, hens were fed diets with graded increments of supplemental Cu (0.0; 3.5; 7.0; 10.5; 14; and 17.5 ppm) from Cu sulfate (CuSO4 5H2O), totaling 2.67; 5.82; 9.38; 12.92; 16.83; and 20.19 ppm analyzed Cu in feeds for 20 weeks. Estimations of Cu requirements were done using exponential asymptotic (EA), broken line quadratic (BLQ), and quadratic polynomial (QP) models. Obtained Cu requirements for hen d egg production and total settable eggs per hen were 6.2, 7.3, and 12.9 ppm and 8.1, 9.0, and 13.4 ppm, respectively, using EA, BLQ, and QP models. The QP model was the only one having a fit for total eggs per hen with 13.1 ppm Cu as a requirement. Hemoglobin, hematocrit, and serum Cu from hens had requirements estimated as 13.9, 11.3, and 18.5, ppm; 14.6, 13.0, and 19.0 ppm; and 16.2, 14.6, and 14.2 ppm, respectively, for EA, BLQ, and QP models. Hatching chick hemoglobin was not affected by dietary Cu, whereas requirements estimated for hatching chick hematocrit and body weight and length were 10.2, 12.3, and 13.3 ppm using EA, BLQ, and QP models; and 6.8 and 7.1 ppm, and 12.9 and 13.9 ppm Cu using EA and BLQ models, respectively. Maximum responses for egg weight, yolk Cu content, and eggshell membrane thickness were 14.9, 12.7, and 15.1 ppm; 15.0, 16.3, and 15.7 ppm; and 7.3, 7.8, and 14.0 ppm Cu, respectively, for EA, BLQ, and QP models. Yolk and albumen percentage were adjusted only with the QP model and had requirements estimated at 11.0 ppm and 11.3 ppm, respectively, whereas eggshell mammillary layer was maximized with 10.6, 10.1, and 14.4 ppm Cu using EA, BLQ, and QP models, respectively. The average of all Cu requirement estimates obtained in the present study was 12.5 ppm Cu.

Broiler responses to increasing selenium supplementation using Zn-L-selenomethionine with special attention to breast myopathies.

A study was conducted to evaluate growth performance, carcass and breast yields, and the occurrence and severity of white striping (WS) and wooden breast (WB) myopathies of broilers fed diets supplemented with increasing dietary levels of an organic source of selenium (Zn-L-SeMet). Broilers were fed 6 treatments with 12 replications of 26 birds in a 4-phase feeding program from 1 to 42 days. Corn-soy-based diets were supplemented with 0, 0.2, 0.4, 0.6, 0.8, and 1.0 ppm of Zn-L-SeMet. At 42 d, 6 birds were randomly selected from each pen (n = 72) and processed for carcass and breast yields. Breast fillets were scored for WS and WB at 42 days. Increasing Zn-L-SeMet led to quadratic responses (P < 0.05) for FCR from 1 to 7 d, BWG from 22 to 35 d, and for both responses from 8 to 21 d and 36 to 42 d, as well as in the overall period of 42 days. Carcass and breast yields presented a quadratic improvement (P < 0.01) with increasing Zn-L-SeMet supplementation and Se requirements were estimated at 0.85 and 0.86 ppm, respectively. In the overall period, estimates of Se requirements were 0.64 ppm for BWG and 0.67 ppm for FCR. White striping and WB scores presented quadratic increases (P < 0.01), and maximum scores were observed at 0.68 and 0.67 ppm, respectively. Broilers fed diets formulated without Se supplementation had a higher percentage of normal fillets compared to other Se supplementation levels (quadratic, P < 0.05). In conclusion, increasing Se supplementation to reach maximum growth performance led to higher degrees of severity of WS and WB. Selenium requirements determined in the present study were significantly higher than the present commercial recommendations.

Estimation of broiler responses to increased dietary methionine hydroxy analogue [DL-2-hydroxy-(4-methylthio) butanoic acid] using linear and nonlinear regression models.

As the first limiting amino acid in corn-soy broiler diets, methionine (Met) is supplemented using commercial synthetic sources as demanded to obtain economic feed formulations. The Met analogue DL-2-hydroxy-4-(methylthio)-butanoic acid (HMTBA) is largely utilized with that objective. This study intended to obtain responses of broilers fed with increasing levels of HMTBA, from 28 to 42 d, such that economic returns can be calculated. A total of 2,106 Cobb × Cobb 500 one-day-old male broilers was randomly placed in 81 floor pens (2.7 m2 each). Birds were fed conventional starter (zero to 14 d) and grower (14 to 28 d) diets. Starting at 28 d of age, pens of 26 birds were randomly allocated into 9 feed treatments with 9 replications having increasing supplementations with HMTBA (0.00, 0.07, 0.14, 0.21, 0.28, 0.35, 0.42, 0.49 and 0.56%). These were prepared by mixing different proportions of corn-soy dilution and summit diets, which had the same formulated concentration of nutrients and energy [19.7% CP, 0.90% Ca, 0.45% Av. P, 0.95% digestible Lys, and 3,150 kcal/kg AMEn], with the exception of HMTBA [0.56% in the summit but not supplemented in the corn-soy dilution diet (0.52% digestible TSAA)]]. Growth performance was evaluated until 42 d when carcass yield and commercial cuts were evaluated using 6 birds randomly taken from each pen. Body weight gain (BWG), feed conversion ratio (FCR), proportion of breast fillets, and abdominal fat were adjusted using linear broken-line, exponential asymptotic and quadratic polynomial regression models (P < 0.05). Estimations of maximum responses for supplemented HMTBA by the linear broken-line model were 0.17% for BWG, 0.14% for FCR, and 0.29% for breast fillets. Using exponential and quadratic regressions, optimized HMTBA supplementations were obtained at 0.34 and 0.35% for BWG, 0.20 and 0.33% for FCR, and 0.31 and 0.36% for breast fillets, respectively. Supplemental levels of HMTBA that optimize growth performance and breast meat in male broilers from 28 to 42 d, using different regression models, varied from 0.14 to 0.36%.

Apparent metabolizable energy of by-products from the soybean oil industry for broilers: acidulated soapstock, glycerin, lecithin, and their mixture.

A study was conducted to determine the AMEn contents of fat by-products from the soybean oil industry for broiler chickens. A total of 390 slow-feathering Cobb × Cobb 500 male broilers were randomly distributed into 13 treatments having 6 replicates of 5 birds each. Birds were fed a common starter diet from placement to 21 d. Experimental corn-soy diets were composed of four fat sources, added at 3 increasing levels each, and were fed from 21 to 28 d. Fat sources utilized were acidulated soybean soapstock (ASS), glycerol (GLY), lecithin (LEC), and a mixture (MIX) containing 85% ASS, 10% GLY and 5% LEC. A 4 × 3 + 1 factorial arrangement was used with 4 by-products (ASS, GLY, LEC, or MIX), 3 inclusion levels and 1 basal diet. Each of the four fat by-product sources was included in the diets as follow: 2% of by-products (98% basal + 2% by-product), 4% (96% basal + 4% by-product), or 6% (94% basal + 6% by-product). Birds were submitted to 94, 96, 98, and 100% of ad libitum feed intake; therefore, the differences in AMEn consumption were only due to the added by-product. Total excreta were collected twice daily for 72 h to determine apparent metabolizable energy contents starting at 25 d. The AMEn intake was regressed against feed intake and the slope was used to estimate AMEn values for each fat source. Linear regression equations (P < 0.05) estimated for each by-product were as follow: 7,153X - 451.9 for ASS; 3,916X - 68.2 for GLY; 7,051X - 448.3 for LEC, and 8,515X - 622.3 for MIX. Values of AMEn were 7,153, 3,916, 7,051, and 8,515 kcal/kg DM for ASS, GLY, LEC, and MIX, respectively. The present study generated AMEn for fat by-products data that can be used in poultry feed formulation. It also provides indications that, by adding the 3 by-products in the proportions present in the MIX, considerable economic advantage can be attained.

Histomorphometric study of the anterior latissimus dorsi muscle and evaluation of enzymatic markers of broilers affected with dorsal cranial myopathy.

Dorsal cranial myopathy (DCM), which affects the anterior latissimus dorsi (ALD) muscles of commercial broilers, is of unknown etiology, and it represents up to 6% of the partial condemnations in Brazilian slaughterhouses. This study was performed to achieve histomorphometric characterizations of the ALD muscles from male Cobb 500 broilers slaughtered at either 35 d or 42 d and to evaluate the effects of DCM on the enzymatic markers aspartate aminotransferase (AST), alanine aminotransferase (ALT), creatine kinase (CK), and lactate dehydrogenase (LDH) and on uric acid and creatinine metabolites. Blood samples (1.5 to 3 mL) and ALD muscle fragments were collected from each carcass, all of which were processed in a commercial inline processing system. For each age, twelve macroscopically normal animals and twelve animals found to exhibit DCM were randomly selected for histomorphometric evaluation and analysis of serologic profiles. Microscopic evaluations demonstrated that the muscle fibers of those with DCM exhibited a strong presence of multifocal regenerative myodegeneration as well as a substitution of muscle tissue with connective tissue (P < 0.001) through fibrosis, thus characterizing the chronicity and hardness of the affected muscle. It is suggested that DCM is a localized muscle lesion because the detected serum levels of CK (P < 0.001), AST (P < 0.001), ALT (P = 0.01), and LDH (P < 0.001) enzymes were strongly associated with the group affected by DCM. Additional studies are needed to gain an understanding of this myopathy because it is an emerging problem in the poultry industry. In addition, it is related to DCM lesions in fast-growing broilers with the greatest slaughter weights.

Occurrence of white striping and wooden breast in broilers fed grower and finisher diets with increasing lysine levels.

Two experiments were conducted to evaluate the prevalence and severity of white striping (WS) and wooden breast (WB) in breast fillets from broilers fed diets with increasing digestible Lysine (dLys) from 12 to 28 d (Exp. 1) and from 28 to 42 d (Exp. 2). Trials were sequentially conducted using one-d-old male, slow-feathering Cobb 500 × Cobb broilers, both with 6 treatments and 8 replicates. Increasing dLys levels were equally spaced from 0.77 to 1.17% in Exp. 1 and from 0.68 to 1.07% in Exp. 2. The lowest dLys diet was not supplemented with L-Lysine (L-Lys) in either one of the studies and all other essential amino acid (AA) met or exceeded current commercial recommendations such that their dietary concentrations did not limit broiler growth. Four birds per pen were randomly selected from each replication and processed at 35 and 42 d in Exp. 1 and Exp. 2, respectively. Deboned breast fillets (Pectoralis major) were submitted to a 3 subject panel evaluation to detect the presence of WS and WB, as well as to provide scores of WS (0-normal, 1-moderate, 2-severe) and WB (0-normal, 1-moderate light, 2-moderate, 3-severe). Increasing the level of dLys had a positive effect on BW, carcass, and breast weight, as well as breast yield. White striping and WB prevalences were 32.3 and 85.9% in Exp. 1 and 87.1 and 89.2% in Exp. 2. Birds fed diets not supplemented with L-Lys had the lowest average WS and WB scores (0.22 and 0.78 in Exp. 1 and 0.61 and 0.68 in Exp. 2). White striping and WB presented linear responses to performance variables in Exp. 1, whereas quadratic responses were observed for all variables in Exp. 2. In conclusion, increasing the level of dLys improved growth performance and carcass traits as well as induced the occurrence and severity of WS and WB lesions.

Age-related energy values of bakery meal for broiler chickens determined using the regression method.

A study was conducted to determine the ileal digestible energy (IDE), ME, and MEn contents of bakery meal using the regression method and to evaluate whether the energy values are age-dependent in broiler chickens from zero to 21 d post hatching. Seven hundred and eighty male Ross 708 chicks were fed 3 experimental diets in which bakery meal was incorporated into a corn-soybean meal-based reference diet at zero, 100, or 200 g/kg by replacing the energy-yielding ingredients. A 3 × 3 factorial arrangement of 3 ages (1, 2, or 3 wk) and 3 dietary bakery meal levels were used. Birds were fed the same experimental diets in these 3 evaluated ages. Birds were grouped by weight into 10 replicates per treatment in a randomized complete block design. Apparent ileal digestibility and total tract retention of DM, N, and energy were calculated. Expression of mucin (MUC2), sodium-dependent phosphate transporter (NaPi-IIb), solute carrier family 7 (cationic amino acid transporter, Y(+) system, SLC7A2), glucose (GLUT2), and sodium-glucose linked transporter (SGLT1) genes were measured at each age in the jejunum by real-time PCR. Addition of bakery meal to the reference diet resulted in a linear decrease in retention of DM, N, and energy, and a quadratic reduction (P < 0.05) in N retention and ME. There was a linear increase in DM, N, and energy as birds' ages increased from 1 to 3 wk. Dietary bakery meal did not affect jejunal gene expression. Expression of genes encoding MUC2, NaPi-IIb, and SLC7A2 linearly increased (P < 0.05) with age. Regression-derived MEn of bakery meal linearly increased (P < 0.05) as the age of birds increased, with values of 2,710, 2,820, and 2,923 kcal/kg DM for 1, 2, and 3 wk, respectively. Based on these results, utilization of energy and nitrogen in the basal diet decreased when bakery meal was included and increased with age of broiler chickens.

Energy and nutrient utilization of broiler chickens fed corn-soybean meal and corn-based diets supplemented with xylanase.

A study was conducted to evaluate the effects of increased levels of a ß-xylanase on energy and nutrient utilization of broiler chickens fed corn-soy diets. A total of 480 slow feathering Cobb × Cobb 500 male broilers were randomly distributed to 10 treatments having 8 replicates of 6 birds each. Birds were fed a common starter diet to d 14 post hatch (3,050 kcal/kg AMEn, 21.7% CP, 1.05% Ca, and 0.53% nPP). The experimental diets were provided afterwards until 25 d. Two experimental diets, a conventional corn/soy-based basal diet (CS) and the basal diet in which 40% of the diet was displaced by corn (CN), were fed as-is or supplemented with 50, 100, 150, or 200 fungal ß-xylanase units (FXU)/kg. Dietary treatments were distributed factorially as a 2 × 5 arrangement. Samples of feed, excreta, and ileal digesta were analyzed for determination of ileal digestible energy (IDE), metabolizable energy, and total tract retention of protein and lipid. No interactions between diet and xylanase were observed. The CS diets had higher (P < 0.05) energy utilization and nutrient digestibility when compared to the CN diets. AMEn and IDE were improved (P < 0.05) by 192 and 145 kcal/kg, respectively, when diets were supplemented with 100 FXU/kg xylanase. The xylanase added to the CN diet led to quadratic increases (P < 0.05) in IDE (Y = - 0.014x(2) + 2.570x + 3,155; r(2) = 0.60) and in AMEn (Y = - 0.016x(2) + 3.982x + 3,155; r(2) = 0.68). Crude protein digestibility and AMEn were linearly increased (P < 0.05) when xylanase was added to the CN diet. In conclusion, energy utilization and digestibility of crude protein and dry matter increased with xylanase supplementation in corn/soy-based diets. When xylanase was tested in the CS diet, 92 and 124 FXU/kg maximized the energy release effect; however, the maximum energy response in the CN diet or corn was not achieved until 200 FXU/kg.

Starch digestibility, energy utilization, and growth performance of broilers fed corn-soybean basal diets supplemented with enzymes.

A study was conducted to evaluate the effects of dietary α-amylase and ß-xylanase supplementation of corn-soy diets, formulated with or without supplemental phytase, on growth performance, energy utilization, and starch digestibility in broiler chickens. A total of 336 slow-feathering, Cobb × Cobb 500 male broilers were randomly distributed to 6 treatments having 8 replicates of 7 birds each. Birds were fed a common starter diet to d 14 post-hatch (3,050 kcal/kg AMEn, 21.7% CP, 1.05% Ca, and 0.53% nPP). The experimental diets were provided afterwards until d 25. A 2 × 3 factorial arrangement of 2 control diets (basal = corn-soy diet without added phytase or PHY = corn-soy diet formulated with 1,000 phytase units/kg) and 3 carbohydrase supplementations (0, 80 kilo-Novo α-amylase units/kg, or 80 kilo-Novo α-amylase units/kg + 100 fungal ß-xylanase units/kg) was used from d 14 to 25. Excreta were collected from 21 to 24 d and all birds were euthanized at 25 d for jejunum and ileum content collection. Samples of feed, excreta, and jejunal and ileal digesta were analyzed for determination of total tract retention and ileal apparent digestibility. No interactions between diet and carbohydrase were observed. Broilers fed diets formulated with phytase or supplemented with amylase + xylanase had higher BW gain (BWG) and lower FCR (P < 0.05) when compared with birds fed diets without carbohydrases. Relative to the basal diet, AMEn was increased (P < 0.01) by 70 kcal/kg and 99 kcal/kg when birds were fed the diet supplemented with amylase and amylase + xylanase, respectively. Starch digestibility in the jejunum and ileum was increased (P < 0.05) by 3.5% and 2.4%, respectively, when birds were fed the diet supplemented with amylase + xylanase. Results from this experiment show that corn-soy diets having phytase and supplemented with amylase and xylanase led to increased growth performance, AMEn, and starch digestibility in broilers. Furthermore, the efficacy of exogenous amylase and xylanase was independent of the presence of microbial phytase.

Digestibility marker and ileal amino acid digestibility in phytase-supplemented soybean or canola meals for growing pigs.

Two experiments using soybean meal (SBM) or canola meal (CM) were conducted to investigate whether the choice of digestibility marker influenced the apparent ileal digestibility (AID) or standardized ileal digestibility (SID) of N and AA in diets supplemented with phytase. In each experiment, 18 barrows fitted with T-cannulas at the ileocecal junction were assigned to 3 diets consisting of a N-free diet to determine endogenous losses of N and AA, a semipurified diet (SBM in Exp. 1 or CM in Exp. 2), and the semipurified diet supplemented with phytase at 1,000 phytase units/kg. Three digestibility markers including acid-insoluble ash (AIA), chromic oxide (Cr2O3), and titanium dioxide (TiO2) were added to each diet at 3 g/kg. Each diet was fed for 7 d, consisting of a 5-d adjustment and a 2-d collection of ileal digesta. In both studies, basal ileal endogenous losses determined with Cr2O3 as a digestibility marker were lower (P<0.01) than with those determined with AIA or TiO2 digestibility markers. Using SBM as the protein source in Exp. 1, there was no interaction between phytase and digestibility marker on AID or SID of AA. The AID of N and AA in SBM using AIA as a digestibility marker tended to be lower (P<0.1) compared with Cr2O3 or TiO2 digestibility markers. Phytase supplementation increased (P<0.001) the AID of Ca and P. The use of AIA or Cr2O3 digestibility marker tended to be associated with lower (P<0.1) SID values compared with TiO2. Phytase did not affect the SID of N or any AA in SBM except for Met, for which there was an increase (P<0.05) with phytase supplementation. Using CM as the protein source in Exp. 2, there were significant interactions between digestibility marker and phytase. Phytase supplementation had effects (P<0.01) on AID or SID when Cr2O3 or TiO2 was used as the digestibility marker. With Cr2O3 or TiO2 as the digestibility marker in the CM diets, phytase supplementation increased (P<0.05) the SID of N and all AA (except Trp). There was no SID of N or AA response to phytase supplementation of CM when AIA was used as a digestibility marker. In contrast, there were no clear improvements in AA digestibility from phytase supplementation for SBM. Phytase effects on AID or SID of AA were dependent on the digestibility marker used in diets when CM was used as the protein source but not when SBM was used as the protein source. Therefore, AA digestibility response to phytase supplementation may depend on the protein being evaluated as well as the choice of digestibility marker.

Formulating poultry diets based on their indigestible components.

Since it started as an organized economic activity, poultry production has been undergoing an evolution toward the optimization of its feed formulation features. Notably, advances in the knowledge of birds' nutrient requirements have allowed recommendations that are increasingly closer to the needs of the birds. Over time, availability of nutrients and energy has been incorporated into those recommendations, especially to compensate for the variability in the digestibility of nutrients originating from variable feed ingredient sources. Instead of using the total energy and nutrient content, current tables of nutrient recommendations provide an estimate of the digestible fractions of the nutrients in ingredients. For instance, nonphytate P is preferred instead of total P to account for the unavailable phytate P, and digestible amino acids to account for the differences in digestibility of amino acids in different ingredients, whereas energy is usually expressed as a proportion that has been digested and metabolized (AME). With the increasing interest in the use of exogenous enzymes in poultry feeds, special attention is directed to the feed substrates such that an added enzyme can match it, forming an enzyme-substrate complex that will be followed by a chemical reaction within the gastrointestinal tract. As a consequence of a degradation reaction, nutrients released can be absorbed and metabolized. In general, nutritional data banks used in linear feed formulation software have limited data on the proportions of fractions of ingredients that are indigestible. Therefore, estimations of the presence of many substrates in the feeds, and therefore the benefits of adding exogenous enzymes, are frequently limited because of the scarcity of adequate information. The objective of this review paper is to provide insights into the use of expanded nutrient databanks to include all the molecules considered potentially indigestible for poultry such that the inclusion of exogenous enzymes allows the estimation of the values of the product originated by their hydrolysis.

Development of bone in chick embryos from Cobb 500 breeder hens fed diets supplemented with zinc, manganese, and copper from inorganic and amino acid-complexed sources.

Sources of Zn, Mn, and Cu (IZMC) as sulfates or as amino acid complexes (OZMC) were used to supplement Cobb 500 breeder hen diets. Experimental treatments consisted of diets supplemented with 1) 100, 100, and 10 mg/kg of Zn, Mn, and Cu, respectively, from IZMC (control); 2) 60, 60, and 3 mg/kg of Zn, Mn, and Cu, respectively, from IZMC plus 40, 40, and 7 mg/kg of Zn, Mn, and Cu, respectively, from OZMC (ISO); and 3) a diet with 100, 100, and 10 mg/kg of Zn, Mn, and Cu, respectively, from IZMC as in control plus 40, 40, and 7 mg/kg of supplemental Zn, Mn, and Cu from OZMC (on top). Ten replications of 20 females and 2 males were used per treatment. Eggs from breeders at 30, 40, 50 and 60 wk of age were incubated, and 5 embryos per replicate were collected at 10 (E10), 14 (E14), and 18 (E18) d of incubation. Midshaft width and calcification were measured for left tibia and femur stained with Alcian Blue and Alizarin Red S. At hatch, the left tibia of 5 chicks per replicate was sampled for histological evaluation of the diaphysis and distal epiphysis. Feeding the ISO treatment compared with the control diet increased the Zn (P < 0.05) but not Mn and Cu content of the yolk and albumen blend. At E14, the ISO and on-top treatments had a trend to increase tibia calcification at the rates of 1.6 and 1%, respectively (P < 0.1). The E18 ISO and on-top treatments had 2% thicker tibia compared with the control, regardless of hen age (P < 0.05). Also, at E18, calcification of tibia and femur was higher from hens fed the on-top treatment (P < 0.05). The chicks from the ISO and on-top groups had increased tibia moment of inertia (P < 0.01) at day of hatch. Broiler breeder hens consuming OZMC associated with IZMC produced embryos and hatching chicks with improvements in selected bone mineralization parameters.

Effects of a monocomponent protease on performance and protein utilization in 7- to 22-day-old broiler chickens.

A study was conducted with an exogenous monocomponent protease added to corn-soybean meal diets fed to straight-run Ross 708 broilers from 7 to 22 d of age. Broilers were randomly placed into 42 battery pens (5 birds/pen) and allocated to 6 treatments with 7 replicates. A positive control diet (PC; 22.5% CP) and a low protein basal diet (20.5% CP) were formulated. Low protein diets (LP) comprised 98.67% of low protein basal diet and 1.33% Celite (indigestible marker and filler; Celite Corp., Lompoc, CA). Protease [75,000 PROT units/g; 1 PROT unit is defined as the amount of enzyme that releases 1 µmol of p-nitroaniline from 1 µM of substrate (Suc-Ala-Ala-Pro-Phe-p-nitroaniline per minute at pH 9.0 and 37°C] was added at the expense of Celite (0 mg/kg, LP0; 100 mg/kg, LP100; 200 mg/kg, LP200; 400 mg/kg, LP400; and 800 mg/kg, LP800) to create the LP diets (20.25% CP). At 22 d of age, ileal contents were collected from all birds for apparent CP and amino acid (AA) digestibility determinations. Broilers fed the PC diet were 7.5% heavier (P < 0.05) compared with those fed the LP0 diet. Birds fed the LP diets containing protease regardless of concentration grew as well as the birds fed the PC diet. Feed conversion was impaired (P < 0.05) in birds fed the LP0 and the LP100 diets compared with those fed the PC diet, but no difference was found between birds fed the PC diet and those fed diets containing more protease (LP200, LP400, and LP800). Digestibility of CP was increased (P < 0.05) in broilers fed the LP-supplemented diets compared with those fed either the PC or LP0 diets, but it was similar between those fed LP diets with any protease concentration. Digestibility of AA was not different between the PC and LP0 diets. The protease used in this study restored live performance and digestibility of CP (6.1%). When benefits in AA digestibility occurred, they were similar at all protease inclusions and averaged as follows: Arg, 3.5%; Ile, 3.2%; Lys, 5.4%; Thr, 7.8%; Asp, 6.5%; His, 3.3%; Cys, 4.6%; and Ser, 5.5%. Methionine was increased only at 400 and 800 mg/kg (6.5%) and Val was increased only at 200 and 800 mg/kg (5%).